Product ID:130-4 PRIMER OMEGA-LACQUERS
MSDS Date:06/11/1993
FSC:8010
NIIN:00F040444
MSDS Number: BXLPT

PLASTI-KOTE INC (TEMPO PRODUCTS CO)

1000 LAKE RD
MEDINA, OH 44256-5000
US

Emergency Phone: 216-725-4511

Info Phone: 216-725-4511

Cage: EO706

TEMPO PRODUCTS CO A PLASTI-KOTE CO INC

MEDINA, OH 44256 US

Telephone: 330-725-4511

Cage: 07708

ACETONE; DIMETHYL KETONE; 2-PROPANONE

CAS: 67-64-1

RTECS: AL3150000

Fraction By Weight: 40-45%

OSHA PEL 2400 MG/CUM

ACGIH TLV: 750 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

ETHYL 3-ETHOXYPROPIONATE, PROPANOIC ACID, 3-ETHOXY-, ETHYL

CAS: 763-69-9

RTECS: UF3325000

Fraction By Weight: 0-5%

ISOBUTYL ACETATE, ESTER

CAS: 110-19-0

RTECS: AI4025000

Fraction By Weight: 0-5%

OSHA PEL 150 PPM

ACGIH TLV: 713 MG/CUM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

2-BUTANONE (METHYL ETHYL KETONE) (MEK)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 0-5%

OSHA PEL 200 PPM

ACGIH TLV: 590 MG/CUM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

XYLENE, DIMETHYLBENZENE, XYLOL (IARC - GROUP 3) *95-2*

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 5-10%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM, SKIN

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

HYDROCARBON PROPELLANT, PETROLEUM GASES LIQUEFIED

CAS: 68476-86-8

Fraction By Weight: 23%

OSHA PEL 1000 PPM

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION: NASAL & RESPIRATORY
IRRITATION/ASPHYXIATION. EYES: SEVERE IRRITATION. INGESTION:
GASTROINTESTINAL IRRITATION. SKIN: CAN CAUSE IRRITATION FOR SOME
PERSONS. REPEATED/PROLONGED OVEREXPOSURE T O SOLVENTS MAY CAUSE
PERMANENT BRAIN & NERVOUS SYSTEM DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DIZZINESS, WEAKNESS, FATIGUE,
NAUSEA, HEADACHE, UNCONSCIOUSNESS, ASPHYXIATION, REDENSS, TEARING,
BLURRED VISION, VOMITING, DIARRHEA

First Aid:INHALATION: REMOVE TO FRESH AIR. GIVE OXYGEN/CPR IF
NECESSARY. EYES: FLUSH W/WATER FOR 15 MINS. INGESTION: DON'T INDUCE
VOMITING. ASPIRATION HAZARD. KEEP WARM & QUIET. SKIN: WASH W/SOAP &
WATER/VARIOU S HAND CLEANERS & WASH CLOTHING. OBTAINMEDICAL
ATTENTION IN ALL CASES.

Flash Point Method:TCC
Flash Point:0F
Lower Limits:1
Extinguishing Media:ALCOHOL FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. USE FOG
NOZZLES TO COOL CLOSED CONTAINERS. USE SCBA W/FULL FACE PIECE
OPERATED IN PRESSURE DEMAND/OTHER POSITIVE PRESSURE MODE.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE/IGNITE WHEN
EXPOSED TO EXTREME HEAT. VAPORS ARE >AIR & MAY TRAVEL ALONG
GROUND/MOVED BY VENTILATION & IGNITE BY IGNITION SOURCES.

Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. VENTILATE
AREA. ABSORB LIQUID ON PAPER W/VERMICULITE, FLOOR ABSORBENT/OTHER
ABSORBENT MATERIAL & TRANSFER TO A CLOSED CONTAINER.

Handling and Storage Precautions:DON'T PUNCTURE/INCINERATE. DON'T STORE
IN AREAS >120F/IN DIRECT SUNLIGHT/NEAR HEAT/OPEN FLAMES.
Other Precautions:STORE LARGE QUANTITIES IN BUILDING PROTECTED FOR
STORAGE OF FLAMMABLE LIQUIDS. AVOID BREATHING VAPORS/SPRAY MIST.
AVOID SKIN & EYE CONTACT.

Respiratory Protection:WEAR NIOSH/MSHA APPROVED RESPIRATOR IF NEEDED.
Ventilation:SUFFICIENT MECHANICAL (GENERAL)/LOCAL EXHAUST TO MAINTAIN
EXPOSURE Protective Gloves:NEOPRENE
Eye Protection:CHEMICAL SPLASH GOGGLES
Other Protective Equipment:OPEN WINDOWS & DOORS/OTHER MEANS TO ENSURE
FRESH AIR ENTRY DURING APPLICATION & DRYING.
Work Hygienic Practices:WASH HANDS BEFORE EATING/USING WASHROOM.
Supplemental Safety and Health
INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING & INHALING THE
CONTENTS MAY BE HARMFUL/FATAL.

Boiling Pt:B.P. Text:133-331F
Melt/Freeze Pt:M.P/F.P Text: 1500F
Vapor Density:>1
Spec Gravity:<1
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:SLIGHT TO MODERATE
Appearance and Odor:TYPICAL SOLVENT PAINT
Percent Volatiles by Volume:80-90

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, SPARKS, OPEN FLAME, ELECTRIC
EQUIPMENT & OTHER IGNITION SOURCES
Hazardous Decomposition Products:CO2, CO, VARIOUS HYDROCARBONS,
NITROGEN COMPOUNDS WHEN BURNED.

Waste Disposal Methods:MATERIAL COLLECTED ON ABSORBENT MATERIAL MAY BE
DEPOSITED IN A POSTED TOXIC SUBSTANCE LANDFILL IN ACCORDANCE
W/LOCAL, STATE & FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.